Substrate competition between methanogens and acetogens during the degradation of methanol in UASB reactors

L. Florencio, James A Field, G. Lettinga

Research output: Contribution to journalArticle

52 Citations (Scopus)

Abstract

To evaluate the effect of methanol concentration and inorganic carbon on the competition between acetogens and methanogens for methanol, eight upflow anaerobic sludge blanket reactors were operated continuously with different levels of sodium bicarbonate at variable methanol loadings. The results indicated that methylotrophic methanogens will predominate in a broad pH range (4.2-7.2) if either the methanol concentration in the effluent or inorganic carbon is low. Continuous steady state methane production resulted in chemical oxygen demand (COD) removals of 99.8-54% at organic loadings ranging from 7.6 to 22 g COD·l-1·d-1. On the other hand, significant acetogenesis occurred if exogenous inorganic carbon was supplied and if the methanol concentration in the effluent was greater than 1000 mg COD·l-1. The observation that acetogenesis only occurred in the presence of high methanol concentrations in the effluent confirms the previously determined 60-times-higher substrate affinity of methanogens. Steady state acetogenesis was only observed when unionized VFA, which inhibited the methanogens, were present at high levels for prolonged periods of time. Addition of moderate levels of NaHCO3 (15 meq·l-1) were found to create such conditions since VFA accumulation exceeded the buffering capacity. Continuous acetogenesis from methanol at organic loading rates of 21 g COD·l-1·d-1 resulted in poor COD removal (16.3%). In contrast, high levels of NaHCO3 supplementation (≥25 meq·l-1) favured methane production since the alkalinity was strong enough to prevent toxic levels of undissociated acids even in periods when VFA accumulated as a result of organic overloading.

Original languageEnglish (US)
Pages (from-to)915-922
Number of pages8
JournalWater Research
Volume29
Issue number3
DOIs
StatePublished - 1995
Externally publishedYes

Fingerprint

Methanogens
methanol
Methanol
substrate
Degradation
degradation
Substrates
inorganic carbon
Effluents
Chemical oxygen demand
effluent
chemical oxygen demand
Carbon
Methane
methane
Sodium bicarbonate
Alkalinity
reactor
buffering
bicarbonate

Keywords

  • acetogenesis
  • granular sludge
  • inorganic carbon
  • methanogenesis
  • methanol
  • substrate competition
  • UASB
  • undissociated VFA

ASJC Scopus subject areas

  • Ecological Modeling
  • Pollution
  • Waste Management and Disposal
  • Water Science and Technology
  • Earth-Surface Processes

Cite this

Substrate competition between methanogens and acetogens during the degradation of methanol in UASB reactors. / Florencio, L.; Field, James A; Lettinga, G.

In: Water Research, Vol. 29, No. 3, 1995, p. 915-922.

Research output: Contribution to journalArticle

@article{7321b907e25e4af191089c2a9c115201,
title = "Substrate competition between methanogens and acetogens during the degradation of methanol in UASB reactors",
abstract = "To evaluate the effect of methanol concentration and inorganic carbon on the competition between acetogens and methanogens for methanol, eight upflow anaerobic sludge blanket reactors were operated continuously with different levels of sodium bicarbonate at variable methanol loadings. The results indicated that methylotrophic methanogens will predominate in a broad pH range (4.2-7.2) if either the methanol concentration in the effluent or inorganic carbon is low. Continuous steady state methane production resulted in chemical oxygen demand (COD) removals of 99.8-54{\%} at organic loadings ranging from 7.6 to 22 g COD·l-1·d-1. On the other hand, significant acetogenesis occurred if exogenous inorganic carbon was supplied and if the methanol concentration in the effluent was greater than 1000 mg COD·l-1. The observation that acetogenesis only occurred in the presence of high methanol concentrations in the effluent confirms the previously determined 60-times-higher substrate affinity of methanogens. Steady state acetogenesis was only observed when unionized VFA, which inhibited the methanogens, were present at high levels for prolonged periods of time. Addition of moderate levels of NaHCO3 (15 meq·l-1) were found to create such conditions since VFA accumulation exceeded the buffering capacity. Continuous acetogenesis from methanol at organic loading rates of 21 g COD·l-1·d-1 resulted in poor COD removal (16.3{\%}). In contrast, high levels of NaHCO3 supplementation (≥25 meq·l-1) favured methane production since the alkalinity was strong enough to prevent toxic levels of undissociated acids even in periods when VFA accumulated as a result of organic overloading.",
keywords = "acetogenesis, granular sludge, inorganic carbon, methanogenesis, methanol, substrate competition, UASB, undissociated VFA",
author = "L. Florencio and Field, {James A} and G. Lettinga",
year = "1995",
doi = "10.1016/0043-1354(94)00199-H",
language = "English (US)",
volume = "29",
pages = "915--922",
journal = "Water Research",
issn = "0043-1354",
publisher = "Elsevier Limited",
number = "3",

}

TY - JOUR

T1 - Substrate competition between methanogens and acetogens during the degradation of methanol in UASB reactors

AU - Florencio, L.

AU - Field, James A

AU - Lettinga, G.

PY - 1995

Y1 - 1995

N2 - To evaluate the effect of methanol concentration and inorganic carbon on the competition between acetogens and methanogens for methanol, eight upflow anaerobic sludge blanket reactors were operated continuously with different levels of sodium bicarbonate at variable methanol loadings. The results indicated that methylotrophic methanogens will predominate in a broad pH range (4.2-7.2) if either the methanol concentration in the effluent or inorganic carbon is low. Continuous steady state methane production resulted in chemical oxygen demand (COD) removals of 99.8-54% at organic loadings ranging from 7.6 to 22 g COD·l-1·d-1. On the other hand, significant acetogenesis occurred if exogenous inorganic carbon was supplied and if the methanol concentration in the effluent was greater than 1000 mg COD·l-1. The observation that acetogenesis only occurred in the presence of high methanol concentrations in the effluent confirms the previously determined 60-times-higher substrate affinity of methanogens. Steady state acetogenesis was only observed when unionized VFA, which inhibited the methanogens, were present at high levels for prolonged periods of time. Addition of moderate levels of NaHCO3 (15 meq·l-1) were found to create such conditions since VFA accumulation exceeded the buffering capacity. Continuous acetogenesis from methanol at organic loading rates of 21 g COD·l-1·d-1 resulted in poor COD removal (16.3%). In contrast, high levels of NaHCO3 supplementation (≥25 meq·l-1) favured methane production since the alkalinity was strong enough to prevent toxic levels of undissociated acids even in periods when VFA accumulated as a result of organic overloading.

AB - To evaluate the effect of methanol concentration and inorganic carbon on the competition between acetogens and methanogens for methanol, eight upflow anaerobic sludge blanket reactors were operated continuously with different levels of sodium bicarbonate at variable methanol loadings. The results indicated that methylotrophic methanogens will predominate in a broad pH range (4.2-7.2) if either the methanol concentration in the effluent or inorganic carbon is low. Continuous steady state methane production resulted in chemical oxygen demand (COD) removals of 99.8-54% at organic loadings ranging from 7.6 to 22 g COD·l-1·d-1. On the other hand, significant acetogenesis occurred if exogenous inorganic carbon was supplied and if the methanol concentration in the effluent was greater than 1000 mg COD·l-1. The observation that acetogenesis only occurred in the presence of high methanol concentrations in the effluent confirms the previously determined 60-times-higher substrate affinity of methanogens. Steady state acetogenesis was only observed when unionized VFA, which inhibited the methanogens, were present at high levels for prolonged periods of time. Addition of moderate levels of NaHCO3 (15 meq·l-1) were found to create such conditions since VFA accumulation exceeded the buffering capacity. Continuous acetogenesis from methanol at organic loading rates of 21 g COD·l-1·d-1 resulted in poor COD removal (16.3%). In contrast, high levels of NaHCO3 supplementation (≥25 meq·l-1) favured methane production since the alkalinity was strong enough to prevent toxic levels of undissociated acids even in periods when VFA accumulated as a result of organic overloading.

KW - acetogenesis

KW - granular sludge

KW - inorganic carbon

KW - methanogenesis

KW - methanol

KW - substrate competition

KW - UASB

KW - undissociated VFA

UR - http://www.scopus.com/inward/record.url?scp=0028983983&partnerID=8YFLogxK

UR - http://www.scopus.com/inward/citedby.url?scp=0028983983&partnerID=8YFLogxK

U2 - 10.1016/0043-1354(94)00199-H

DO - 10.1016/0043-1354(94)00199-H

M3 - Article

AN - SCOPUS:0028983983

VL - 29

SP - 915

EP - 922

JO - Water Research

JF - Water Research

SN - 0043-1354

IS - 3

ER -